廢液酒精高效回收裝置 Efficient Waste Liquor and Alcohol Recycling Equipment

聯系人: 銷售部
電話: 028-85408899 15882331886
郵箱: Webmaster@cdgzkj.com
發布人: 川大干燥
留言咨詢 更多信息
分享:
關鍵詞: 酒精回收   回收裝置        

產品介紹

一、工作原理及應用范圍介紹Introduction of Working Principle and Scope of Application


該設備是利用酒精沸點低于水及其溶液沸點的原理,用稍高于酒精沸點的溫度,將需回收的酒精溶液進行加熱蒸發,經塔體精餾后蒸發出高濃度酒精蒸氣,再經冷凝器冷卻回收,獲得符合濃度要求的酒精。

適用于制藥、輕工、化工等行業稀酒精自動回收,同時也適用于甲醇等其它溶媒的精餾。該系統可根據用戶要求,將30度左右的稀酒精精餾至93度以上(體積濃度比)的酒精。

        This principle that the boiling point of alcohol is lower than that of the water and solution is adopted by the equipment; the alcohol resolution to be recycled is heated for evaporation at the temperature higher than the boiling point of alcohol; the high-concentration alcohol steam is obtained after rectificationin the tower and obtained after being cooled by the cooler, finally obtaining the alcohol with required concentration.

         It is applicable to automatic recycling of dilute alcohol of pharmacy, light industry and chemical industry and to therectification of methanol and other solvents. This system can rectify the dilute alcohol about 30 degree to the alcohol over 93 degree (volume concentration ratio) as required by the customer.

 

二、特點Characteristics


1.     連續式回收工藝,回收率大于95%,塔底廢液中含料低,產品濃度穩定,蒸餾效率高,運行費用低,投資省。

2.     回收酒精后,本設備采用外加熱自然循環與真空負壓蒸發方式,蒸發速度快,濃縮比重大,液料在全密封無泡沫狀態下進行濃縮。

3.     收膏時不需在加熱器內進行,關閉加熱器上下蝶閥,在蒸發器內底部收膏即可,比重可達1.35以上。

4.     本設備可自動排水,減輕勞動強度,有半自動化功能,定貨時需注明是否需要自動排水。

1. The continuous recycling process is adopted to achieve over 95% of recovery rate, low material content of the waste liquor at the bottom of tower, stable concentration of product, high rectification efficiency, low operation cost and saving investment.

2. The external heating natural circulation and vacuum evaporation are adopted by the equipment after recycling the alcohol to provide the fast evaporation and high concentration ratio; the liquid is concentrated in fully sealed status without foam.

3. The extract collection is not required to be conducted in the heater, but can be conducted at the bottom of evaporator with upper and lower butterfly valves of heater closed; and the proportion is over 1.35.

4. The equipment is capable of discharging water automatically to reduce the labor intensity, and is provided with the semi-automatic function; it is required that whether the automatic discharge function is needed shall be noted when the order is placed.

 

三、工藝流程圖Process flow diagram

1.jpg

四、技術參數(下表中數值僅供選型時參考)

Technical parameters (the values in the table below are for reference in type selection only)

1.jpg


川大干燥為您提供制藥、食品、化工、農林、飼料裝備,歡迎來電咨詢!

CopyRight ? 版權所有: 四川川大干燥科技工程有限責任公司 技術支持:縱橫天下 網站地圖 XML 備案號:蜀ICP備17001860號-1

本站關鍵字: 干燥設備 混合設備 粉碎設備 篩分設備 制藥設備 食品設備 飼料設備


掃一掃訪問移動端
免费AV片在线观看